johnkarl

I have seen this photo and seen the video thanks, however my relay board is totally different to this one, thanks for helping mate, much appreciate your time looking for the suspension relay, but this is not the same as mine, you would have thought with the number of written advice on the problems this relay has caused, some one would have posted a picture of it, but my search goes on, thanks again

Ihave gone down a different road to test the air bags for leaks, i have cut the pipes from the air control valve [ red,black,blue and green ] and i have fitted shrider valves to each individual pipe, i have then pumped up the suspension to the highest point on each air bag, i have then done the soapy water test and could not see any bubbles indicating a leak anywhere, they have all been up now for 3 days with no sign of any drooping from any corner, once i am satisfied that the air bags are fine [ two weeks should do it ] i will then drop it down to a more manageable Hight, no rush at all, still have not located the position of the suspension pump relay, this is an ongoing problem, cant find a photo or video for my uk car anywhere

On my A6 2001 allroad, the suspension module is located in the rear passenger side, if in the UK, forward from the multi cd player, you can just say see the side of it, looks a pig to get at

yes mate all fuses checked, just had my friend over with his ridiculous priced Snap-On diagnostic and it says that the suspension ECU has no communication, so i am assuming that this is the cause of the problem, looks a bit of a faf to get it out, but we will see

Thank you , will give it a go with my garage compressor and check for leaks

I can't test it because it wont pump it up past the control box mate, i was wondering if i could use my garage compressor to test for leaks to each unit from the control block

Hello everyone, i have purchased an Audi a6 allroad 2.5, i got the car very cheap but as you would expect it has its problems, i have worked my way through quite a few of these but i seem to have hit a wall on the information side. The problem i am facing is the air suspension, the pump will not turn at all, i have removed the pump and just as the man said from whom i bought it from, the pump has been overhauled, i have proved the pump with a direct feed, it works fine with plenty of compression, however when i connect it back to the cars electrics i get nothing, i have bought a new relay as i have been told that this is more than likely the culprit, now here is the part where i have hit the wall, i can't find a single photo of the location of this relay, i was hoping that someone has a photo showing where it goes, then i can eliminate the relay and move on to the next suspect, hope someone can help, thank you for reading my post

Yes the problem is sorted

Found it, changed it, job done

has anyone got a fuel temp sensor wiring plug top with a couple of inches of the harness wire left on [two pin] as the wires have snapped off right at the plug on mine

Can anyone tell me where to locate the crankshaft sensor on a 1.9 tdi 130 2004 engine, pictures would be a godsend, cheers

Just like to say hello to everyone on the forum